BMW K bikes (Bricks)


You are not connected. Please login or register

View previous topic View next topic Go down  Message [Page 1 of 1]


1Back to top Go down   fuel pump problem Empty fuel pump problem Sun May 08, 2022 11:51 pm

cfmckay

cfmckay
active member
active member
I have utilized crazy frogs very detailed information on this forum to trouble shoot a fuel pump problem. These are the things that I know after approx. 40 hours of trouble shooting. The pump is good, hard wired it runs fine. I have 12 volts at the green/white wire to the pump when I press the starter button, remove pump check voltage at pump 12 when start button is pressed. I have confirmed good ground and all parameters according to crazy frogs guide for the fuel pump trouble shooting. Again, 12v from fuse block to the starter relay all the way to the pump. I have replaced the tank connector with the 4 pin connector removed from the relay box. It would seem that any time the starter is in the circuit the fuel pump does not work even though the meter tells me the pump is receiving 12 volts. My suspicion is that the starter is some how disrupting the ground connection for the pump. Anyone have any thoughts on this??? I would greatly appreciate some input. Thanks, Craig

    

2Back to top Go down   fuel pump problem Empty Pump problem Mon May 09, 2022 1:00 am

daveyson

daveyson
Life time member
Life time member
This sounds similar to one of the problems in an old thread, recently revived, called "troubleshooting a 1985 k100 that won't start, stay running" the fuel injection relay was the cause in that case. It was as if the relay was weak, still working with smaller loads, but unable to cope with the added load of the fuel pump. The thread gives more details.

Check that the relay pins and sockets are clean (with electrical contact cleaner) tight and properly engaged. If that checks out, one thing to try would be a jumper wire between both 87 pins of the fuel injection relay socket, then replacing the fuel injection relay (5 pins) with the horn relay (4 pins) If the pump and starter then work at the same time, you want to get another fuel injection relay. If that's what you need you can probably get one at the local junkyard if they have BMW's there. It's light green with five pins, part number 6136 8 373 700.

If you already have another fuel pump relay, don't bother with the jumper wire and horn relay, just swap fuel pump relays to see if that solves the problem.


__________________________________________________
11/1985 bmw k100rt (late model)  Vin. 0090567
 ~120,000 km
    

3Back to top Go down   fuel pump problem Empty Re: fuel pump problem Mon May 09, 2022 6:22 pm

cfmckay

cfmckay
active member
active member
I had the opportunity to further trouble shoot the problem, suffice to say I screwed up on the diagnosis big time. I installed a new starter, I keep a spare and that of course had no effect. So I scanned the  the schematic again and I discovered that I had been checking the wrong relay connections. On my bike the load shed relay and the fuel pump relay are one and the same. I performed all the checks again and discovered that indeed the relay looks like the culprit. I have ordered a new relay and will receive it this week, another weekend in the shed, but I have learned a lot about the electrics of the bike. Hopefully the relay will solve the problem as the symptoms are as you have described. Thank you for taking the time to reply to my question, I appreciate it, Craig

    

4Back to top Go down   fuel pump problem Empty Re: fuel pump problem Mon May 09, 2022 6:47 pm

92KK 84WW Olaf

avatar
Life time member
Life time member
cfmckay wrote:I had the opportunity to further trouble shoot the problem, suffice to say I screwed up on the diagnosis big time. I installed a new starter, I keep a spare and that of course had no effect. So I scanned the  the schematic again and I discovered that I had been checking the wrong relay connections. On my bike the load shed relay and the fuel pump relay are one and the same. I performed all the checks again and discovered that indeed the relay looks like the culprit. I have ordered a new relay and will receive it this week, another weekend in the shed, but I have learned a lot about the electrics of the bike. Hopefully the relay will solve the problem as the symptoms are as you have described. Thank you for taking the time to reply to my question, I appreciate it, Craig

On some of the Ks you can swap the fuel pump relay and the horn relay. . . . .


__________________________________________________
1992 K100LT 0193214 Bertha Blue 101,000 miles
1984 K100RT 0022575 Brutus Baja Red 578 bought 36,000 now 89,150 miles
1997 K1100LT 0188024 Wotan Mystic Red 689 58,645 now 106,950 miles Deceased.
1983 K100RS 0011157 Fricka 606 Alaska Blue 29,495 miles Damn K Pox Its a Bat outta Hell Now 58,200 miles. 
1996 K1100LT 0233004 Lohengrin Mystic Red 38,000 miles currently 48,061 miles.
1983 K100RS 0004449 Odette R100 colours 58,000 miles. Sprint fairing now 61,190 miles

Past:
1968 Yamaha 80 YG1
1971 Yamaha 125 YAS-1
1968 Honda 125 SS
1970 Honda CD 175
1973 Honda CB500-4
Honda CX 500
    

5Back to top Go down   fuel pump problem Empty Re: fuel pump problem Mon May 09, 2022 8:44 pm

Point-Seven-five

Point-Seven-five
Life time member
Life time member
I'm thinking it would be cool to know what year and model bike you're talking about here, but unfortunately, I'm too lazy to search the forum to find where it might have been posted if it ever was.


__________________________________________________
Present: 1991 K100RS "Moby Brick Too"
 
Past:
1994 K75RT "Ilsa, She Wolf of the SS"
1988 K100RS SE "Special Ed"
1994 K75S "Cheetos"
1992 K100RS "Moby Brick" R.I.P.
1982 Honda FT500
1979 Honda XR185
1977 Honda XL125
1974 Honda XL125
1972 OSSA Pioneer 250
1968 Kawasaki 175
    

6Back to top Go down   fuel pump problem Empty Re: fuel pump problem Tue May 10, 2022 8:08 pm

Porto

Porto
Silver member
Silver member
Hi, that was my 85 K100rt in an earlier post with similar problems.
I had a few problems all at once.
Main two problems,
I had a shorting starter button causing power to cut out at low revs.
And also had a faulty new fuel pressure regulator.
I was looking in all the wrong places for a fault. But learned a lot doing it.

https://gpleather.com
    

7Back to top Go down   fuel pump problem Empty fuel pump problem Sat May 14, 2022 11:43 pm

cfmckay

cfmckay
active member
active member
Solved the fuel pump issue, it was in fact a defective fuel pump relay. Thank you for the help, you know who you are and I do not appreciate snide remarks from other posters. If you had looked at my avatar you would clearly see a BMW K100RS with a sidecar.

    

8Back to top Go down   fuel pump problem Empty Re: fuel pump problem Sun May 15, 2022 12:36 am

Point-Seven-five

Point-Seven-five
Life time member
Life time member
You might notice that the inmates list the model(s) they own and in some cases include VIN's.  BMW changed numerous details in these machines during the production run.  These changes can affect troubleshooting, especially with regard to relays and electrical systems.

When you come here asking for help it makes it a little easier for the inmates if you share a little information about your particular machine.  Did you really expect the inmates to look at your avatar to identify what model and year you are having a problem with?  As luck would have it, the bike in your photo that is hidden behind a sidecar and another bike could be an early K100RS, a later K100RS 2v, a K100RS 16V, or even a K1100RS.  All of these bikes have differences that could have a bearing on the problem you were having.  It is a bit presumptuous to come here asking for help and not bothering to share information about your machine.


__________________________________________________
Present: 1991 K100RS "Moby Brick Too"
 
Past:
1994 K75RT "Ilsa, She Wolf of the SS"
1988 K100RS SE "Special Ed"
1994 K75S "Cheetos"
1992 K100RS "Moby Brick" R.I.P.
1982 Honda FT500
1979 Honda XR185
1977 Honda XL125
1974 Honda XL125
1972 OSSA Pioneer 250
1968 Kawasaki 175
    

9Back to top Go down   fuel pump problem Empty Re: fuel pump problem Mon Jun 13, 2022 5:42 pm

Porto

Porto
Silver member
Silver member
Hi, I’ve just the same relay problem, went straight to it after this thread. I’m going to do the relay mod on the lighting system now after reading about that. Would be worth your while checking that thread out. Cheers
Porto

https://gpleather.com
    

10Back to top Go down   fuel pump problem Empty Re: fuel pump problem Mon Jun 13, 2022 7:53 pm

92KK 84WW Olaf

avatar
Life time member
Life time member
cfmckay wrote:Solved the fuel pump issue, it was in fact a defective fuel pump relay. Thank you for the help, you know who you are and I do not appreciate snide remarks from other posters. If you had looked at my avatar you would clearly see a BMW K100RS with a sidecar.
True, but you can't tell from the photo if its a 8v or 16v bike and they differ. I have an 83 and an 84K and lots of difference even in those.


__________________________________________________
1992 K100LT 0193214 Bertha Blue 101,000 miles
1984 K100RT 0022575 Brutus Baja Red 578 bought 36,000 now 89,150 miles
1997 K1100LT 0188024 Wotan Mystic Red 689 58,645 now 106,950 miles Deceased.
1983 K100RS 0011157 Fricka 606 Alaska Blue 29,495 miles Damn K Pox Its a Bat outta Hell Now 58,200 miles. 
1996 K1100LT 0233004 Lohengrin Mystic Red 38,000 miles currently 48,061 miles.
1983 K100RS 0004449 Odette R100 colours 58,000 miles. Sprint fairing now 61,190 miles

Past:
1968 Yamaha 80 YG1
1971 Yamaha 125 YAS-1
1968 Honda 125 SS
1970 Honda CD 175
1973 Honda CB500-4
Honda CX 500
    

11Back to top Go down   fuel pump problem Empty Re: fuel pump problem Mon Jun 13, 2022 11:46 pm

Porto

Porto
Silver member
Silver member
My one is a 85 , 4v.
I one e had a shorted starter. The wires would touch as I would take off with vibration. This was cutting power to the all but needed electrics. Took me ages to find that one. Cheers

https://gpleather.com
    

12Back to top Go down   fuel pump problem Empty Re: fuel pump problem Mon Jun 13, 2022 11:50 pm

Porto

Porto
Silver member
Silver member
fuel pump problem 0c96af10

https://gpleather.com
    

13Back to top Go down   fuel pump problem Empty Re: fuel pump problem Tue Jun 14, 2022 7:06 am

moriarti

moriarti
Life time member
Life time member
A happy ending to the problem. Ks look alike sound alike ride alike,BUT are not alike, The VIN No is the DNA of all Ks without it we are working in the dark, people get upset, egos get bruised, when all we are doing is trying to HELP. SO dear members new or old PLEASE PLEASE include your VIN No cheers  There endeth the first lesson   Worship


__________________________________________________
1984 k100 rs red/black VIN  0004449 Now sold to Olaf
    

Sponsored content


    

View previous topic View next topic Back to top  Message [Page 1 of 1]

Permissions in this forum:
You cannot reply to topics in this forum